CPD庐 PAVER AND CONCRETE SEALER
DESCRIPTION APPLICATION
CPD庐 Paver and Concrete Sealer may be applied by roller,
CPD庐 Paver and Concrete Sealer is a clear solvent base
brush or sprayer depending on surface texture. If spraying,
methacrylate copolymer resin sealer for interlocking
hold nozzle close to surface so as not to atomize the
pavers and concrete and is available in gloss, flat and
solvent carrier, especially in hot weather. One coat is
anti-slip finishes.
recommended; however if a second coat is applied, it
should be applied in the opposite direction. At 21掳C (70掳F)
WHERE TO USE
CPD庐 Paver and Concrete Sealer will dry tack free in
This product can be used as a sealer for interlocking
approximately 30 minutes. Do not apply sealer when the
pavers on sidewalks and driveways, on horizontal and
substrate is in direct sunlight.
vertical exterior concrete surfaces and as a warehouse
floor sealer.
LIMITATIONS
鈥? do not apply to damp or wet surfaces
BENEFITS
鈥? do not apply below 5掳C (40掳F)
鈥? gives paver a color enhancing wet look (gloss finish)
鈥? protect from rain until dry
鈥? protects against penetration of moisture, deicing salts,
rust, oil and grease
鈥? will not yellow on exterior exposure COVERAGE
5-7 m虏/L (200-280 ft虏/U.S. gal) depending on porosity and
鈥? available in gloss, flat and anti-slip finishes
surface texture.
PREPARATION
The ideal surface is a new surface. CPD庐 Paver and STANDARDS
Concrete Sealer should be applied directly after the Approved by the Ministry of Transportation of Ontario
paving stones are installed and cleaned and allowed to (MTO) for use on vertical concrete surfaces (Test M1-
dry completely or the concrete surface is dry. Previously 127).
installed paving stones or existing concrete surfaces must
be clean and dry, free from all grease, oil, laitence and PACKAGING
other foreign matter. If doubt exists as to the condition of 208L drum (55 US gal)/ 210 kg (462 lb)
the surface, chemical cleaning is recommended. Under no 18.9L pail (5 US gal)/ 18 kg (39.6 lb)
conditions should paving stones or concrete surfaces be 3.79L can (1 US gal) (4 per case)/ 16 kg (35.2 lb) per case
cleaned by sand blasting. Contact a CPD庐 Technical
Representative for a cleaning recommendation if doubt CLEAN UP
Clean equipment with CPD庐 Xylol immediately after
exists as to the condition of the concrete surface.
application. CAUTION: CPD庐 Xylol is a flammable
Interlocking pavers must be cleaned of all efflorescence solvent. Review M.S.D.S. prior to using.
using a dilute solution (6 to 1) of Sure Klean庐 Heavy
Duty Concrete Cleaner. Apply as per directions. STORAGE
Thoroughly rinse and allow to dry completely prior to Store in a dry location. Freezing will not affect product
application of CPD庐 Paver and Concrete Sealer. but temperature of product before use must be 15掳C
Interlocking pavers that have been cleaned using high (60掳F) minimum.
water pressure will require a longer drying time due to the
amount of moisture forced in and around the pavers. TRANSPORTATION REGULATION
Application of CPD庐 Paver and Concrete Sealer before Regulated Dangerous Good. Flammable Liquid: (Xylene)
pavers are dry will entrap moisture and turn the surface Class 3/9.2) UN 1307 PG III.
white.
0719-01-1105
SAFETY PRECAUTIONS
Flammable liquid. Consult Material Safety Data Sheet
(M.S.D.S.) for specific instructions. MSDS # 2.
SHELF-LIFE
Two years from date of manufacture when stored in
original unopened containers.
WARRANTY
The recommendations made and the information herein is
based on our own and independent laboratory experience,
and is believed to be accurate under controlled conditions.
However, no warranty or guarantee of accuracy is made
because we cannot cover every possible application of
product nor anticipate every variation encountered in
weather conditions, job-conditions, methods used and
types of surfaces on which the product is applied. The
users shall make their own tests to determine the
suitability of such products for any particular purpose.
CPD庐 makes no warranties with respect to this product,
expressed or implied, without limitation, the implied
warranties of merchantability or fitness for a particular
purpose.
CPD庐鈥? liability shall be limited in all events to supplying
s
sufficient product to re-treat and/or repair the specific
area to which CPD庐 product has been applied. CPD庐
reserves the right to have the true cause of any difficulty
determined by accepted test methods. CPD庐 shall have
no other liability, including liability for incidental,
consequential or resultant damages, however caused,
whether due to breach of warranty, negligence, or strict
liability.
THIS WARRANTY MAY NOT BE MODIFIED OR
EXTENDED BY REPRESENTATIVES OF CPD庐, ITS
DISTRIBUTORS OR DEALERS.
|