CPD庐 20 MINUTE SET
water per 25kg (55 lb) bag of CPD庐 20 Minute Set. Mix
DESCRIPTION
CPD庐 20 Minute Set is a ready-to-use, fast curing, high approximately 2 minutes and place without delay.
strength concrete repair compound with exceptional bond
strength. Applications subjected to freeze-thaw cycles and thin
patches should incorporate the use of CPD庐 Concentrated
Latex Adhesive. CPD庐 Concentrated Latex Adhesive
WHERE TO USE
Used to repair: should be diluted 1:2 with water and used as an integral
鈥? curbs and gutters, sewer pipes, parking decks, piers, part of the mix. Do not exceed 3.5L (0.78 U.S. gal) of
abutments, pre-cast and cast-in-place concrete, concrete water per 25kg (55 lbs.) bag of material.
piles and swimming pools
PLACING
Do not mix more than can be effectively placed in 15
BENEFITS
鈥? initial set in 20 minutes and is hard in one hour minutes. This is especially important in warm weather.
鈥? traffic or other service conditions can resume within Do not re-temper. All freshly placed material should be
cured with CPD庐 Acrylic Cure and Seal. Patches that
hours of application
contain CPD 庐 Concentrated Latex Adhesive should be
鈥? non-metallic, non-staining and non-toxic
cured with CPD庐 Acrylic Cure and Seal (Water Base).
鈥? available in winter and summer grade
For most applications, use the product straight from the
PROPERTIES
Compressive Strengths (Trowelable Consistency) bag and mix with potable water. For exceptionally large or
(ASTM C-109-98) @ 24掳C (75掳F) deep repairs (2" (50mm) or more), clean washed pea
gravel may be added 50% by volume or weight of the
1 hour 24 hours 7 days 28 days patching compound.
3.5MPa 13.8MPa 34.5MPa 48.3MPa
500psi 2000psi 5000psi 7000psi LIMITATIONS
鈥? not suitable for constant immersion
Bond Strength (after 7 days): 6.9MPa 鈥? do not use below 0掳C (32掳F)
1000+ psi 鈥? not suitable for structural grouting
鈥? minimum thickness 6.4mm (1/4")
Set Time at room temperature using a trowelable mix:
Initial - 10-15 minutes COVERAGE/YIELD
Final - 25-30 minutes 0.013m鲁 (0.46 ft鲁) per 25 kg (55 lb.) bag
The above information is representative of actual PACKAGING
production runs. Independent test results may vary from 25 kg (55 lb) multi wall bags.
the above by approximately 卤 10%.
CLEAN UP
Clean all tools and equipment with potable water before
APPLICATION
product sets.
SURFACE PREPARATION
The surface to be repaired should be rough, clean and
wetted with water prior to application. STORAGE
May be stored anywhere short term under a tarp on a
pallet as long as the product is kept dry. For long term
MIXING INSTRUCTIONS
CPD庐 20 Minute Set should be applied in a stiff, no storage, store in a heated warehouse.
slump consistency so that forms or other types of
containers are unnecessary. Use 3.5L (0.78 US gal) of
0392-01-1105
SHELF LIFE
Two years when stored under normal heated warehouse
conditions.
SAFETY PRECAUTION
Consult Material Safety Data Sheet (M.S.D.S.) for
specific instructions. MSDS # 11.
WARRANTY
The recommendations made and the information herein is
based on our own and independent laboratory experience,
and is believed to be accurate under controlled conditions.
However, no warranty or guarantee of accuracy is made
because we cannot cover every possible application of
product nor anticipate every variation encountered in
weather conditions, job-conditions, methods used and
types of surfaces on which the product is applied. The
users shall make their own tests to determine the suitability
of such products for any particular purpose.
CPD庐 makes no warranties with respect to this product,
expressed or implied, without limitation, the implied
warranties of merchantability or fitness for a particular
purpose.
CPD庐 鈥? liability shall be limited in all events to supplying
s
sufficient product to re-treat and/or repair the specific area
to which CPD庐 product has been applied. CPD庐 reserves
the right to have the true cause of any difficulty determined
by accepted test methods. CPD庐 shall have no other
liability, including liability for incidental, consequential or
resultant damages, however caused, whether due to breach
of warranty, negligence, or strict liability.
THIS WARRANTY MAY NOT BE MODIFIED OR
EXTENDED BY REPRESENTATIVES OF CPD庐 ITS
DISTRIBUTORS OR DEALERS.
|