Material Safety Data Sheet
Page 1 of 6 Issue date: July 2006
GC ADHESIVE
1. IDENTIFICATION OF THE MATERIAL AND SUPPLIER
Product Name: GC ADHESIVE
Manufacturer's Product Code: MGM070A
Use: Speciality adhesive for transducers.
DAVIDSON MEASUREMENT PTY LTD
1-3 Lakewood Blvd.
BRAESIDE 3195 VIC
Tel: 61 3 9580 4366
Fax: 61 3 9580 6499
2. HAZARDS IDENTIFICATION
NOT CLASSIFIED AS HAZARDOUS ACCORDING TO ASCC/NOHSC/EU CRITERIA
Hazard Category: Irritant (Xi), Flammable
Hazard Classification: NON-HAZARDOUS SUBSTANCE, NON-DANGEROUS GOOD
RISK PHRASES
R10 Flammable
R36 Irritating to eyes
SAFETY PHRASES
S7 Keep container tightly closed.
S16 Keep away from sources of ignition - No smoking.
S24/25 Avoid contact with skin and eyes.
S26 In case of contact with eyes, rinse immediately with plenty of water and contact a doctor or Poisons Information
Centre.
S38 In case of insufficient ventilation, wear suitable respiratory protection.
Road Transport
UN Number: 1263
Proper Shipping Name: PAINT or PAINT RELATED MATERIAL
Dangerous Goods Class: 3
Packing Group: III
Poison Schedule: None allocated [Aust].
Warning Statement:
This product is a flammable material. Avoid all sources of ignition, heat and naked flames. Will cause irritation to the
eyes.
3. COMPOSITION / INFORMATION ON INGREDIENTS
SUBSTANCE NAME Proportion CAS Number
SILICON CARBIDE 30 to < 60 % 409-21-2
WATER 10 to < 30 % 7732-18-5
ALUMINIUM OXIDE 10 to < 30 % 1344-28-1
PHOSPHORIC ACID 1 to < 10 % 7664-38-2
AMORPHOUS SILICA 1 to 5 % 7631-86-9
BORIC ACID 1 to < 5 % 10043-35-3
ETHANOL 1 to 5 % 64-17-5
All other ingredients not hazardous according to ASCC/NOHSC/EU Criteria.
Material Safety Data Sheet
Page 2 of 6 Issue date: July 2006
GC ADHESIVE
4. FIRST AID MEASURES
Swallowed:
If swallowed, DO NOT induce vomiting. If victim conscious, give 1 to 2 glasses of water to drink. Seek urgent medical
assistance.
Eye:
If material is splashed into eyes, flush with plenty of water for at least 15 minutes, ensuring eye lids are held open.
Immediately transport to hospital or doctor.
Skin:
If material is splashed onto the skin, remove any contaminated clothing and wash skin thoroughly with soap and water.
If irritation persists immediately transport to hospital or doctor.
Inhaled:
Remove victim to fresh air. Apply resuscitation if victim is not breathing - Administer oxygen if breathing is difficult.
Transport to hospital or doctor immediately.
First Aid Facilities:
Eye wash fountain, safety shower and normal wash room facilities.
Advice to Doctor:
Treat symptomatically.
In case of poisoning, contact Poisons Information Centre
In Australia call Tel: 131126
In New Zealand Tel: 034747000
5. FIRE-FIGHTING MEASURES
Fire/Explosion Hazard
SUITABLE EXTINGUISHING MEDIA: Water fog, foam, dry chemical or carbon dioxide.
HAZARDS FROM COMBUSTION PRODUCTS: Decomposes on heating emitting oxides of carbon, elemental
entitities, phosphates and noxious smoke.
PRECAUTIONS FOR FIRE FIGHTERS AND SPECIAL PROTECTIVE EQUIPMENT: Self-contained
breathing apparatus (SCBA) required for fire-fighting personnel. If possible to do so safely, shut off fuel to fire.
HAZCHEM CODE: 3[Y] [Aust]
FLAMMABILITY
This material is a FLAMMABLE liquid. Avoid all source of ignition, heat and naked flames.
Flash Point: 32.2掳C
Flammability Limits: Not available.
Note: This product is a water-based formulation that contains 5 % alcohol. When the liquid component separates from
the solids, the liquid has a closed-cup flash point of 32.2掳C.
6. ACCIDENTAL RELEASE MEASURES
Emergency Procedures:
Flammable liquid. Avoid all sources of ignition. Keep unnecessary people away; Isolate hazard area and deny entry.
Ventilate area. Wear suitable protective equipment as outlined under personal protection in this MSDS.
Methods and Materials for Containment and Clean Up Procedures:
Throw vermiculite or diatomaceous earth onto spill. DO NOT use sawdust. ALLOW TO ABSORB. Use non-sparking
tools or HEPA vacuum system to pick up. Place into labelled drum for later disposal.
Material Safety Data Sheet
Page 3 of 6 Issue date: July 2006
GC ADHESIVE
6. ACCIDENTAL RELEASE MEASURES (Continued)
Emergency information(Transport):
Dangerous Goods - Initial Emergency Response Guide (SAA/SNZ HB76:2004)
For LIQUIDS - Flammable, Guide No: 15
7. HANDLING AND STORAGE
Precautions for Safe Handling:
Flammable liquid. Avoid ignition sources. Do not get in eyes. Avoid direct or prolonged contact with skin. Provide
adequate ventilation.
Conditions for Safe Storage:
Keep containers tightly closed, when not using the product. Store in original packages as approved by manufacturer.
Store in an area that is dry and well-ventilation away from ignition sources. Store at ambient (room temperature)
conditions. The floor of the depot should be impermeable. Store away from strong alkalis and oxidizing agents. For
further information please refer to the Engineering Controls of this MSDS.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Exposure Standards
No exposure standards are available for this product, however, the following exposure standards have been assigned by
[ASCC/NOHSC] to the following components of the product:
SILICON CARBIDE
[ASCC/NOHSC]
[TWA] 10 mg/m3
References: H
ALUMINIUM OXIDE
[ASCC/NOHSC]
[TWA] 10 mg/m3
References: H
PHOSPHORIC ACID
[ASCC/NOHSC]
[TWA] 1 mg/m3
[STEL] 3 mg/m3
References: H
AMORPHOUS SILICA
[ASCC/NOHSC]
[TWA] 2 mg/m3
BORIC ACID
[ASCC/NOHSC]
[TWA] 5 mg/m鈮?
ETHANOL
[ASCC/NOHSC]
1,880 mg/m3
[TWA] 1,000 ppm
References: H
Material Safety Data Sheet
Page 4 of 6 Issue date: July 2006
GC ADHESIVE
8. EXPOSURE CONTROLS / PERSONAL PROTECTION (Continued)
Engineering Controls
Flammable liquid. Maintain adequate ventilation at all times. Prevent accumulation of vapours in hollows or sumps.
Eliminate any sources of ignition.
Personal Protection Equipment
GLOVES: Butyl rubber, nitrile rubber.
EYES: Chemical goggles or spectacles to protect eyes.
RESPIRATORY PROTECTION: Avoid breathing of vapours. Filter capacity and respirator type depends on
exposure levels and type of contaminant. Select and use respirators in accordance with AS/NZS 1715/1716. When
vapours exceed the exposure standards then the use of a half-face respirator fitted with an organic vapour cartridge is
recommended.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Black-gray paint slurry with slight fruity odour.
Boiling Point: ~ 93.3掳C
Vapour Pressure: 10 to 20 mmHg
Specific Gravity: 1.8
Flash Point: 32.2掳C
Flammability Limits: Not available.
Solubility in Water: Dilutable.
Other Properties
Evaporation Rate (BuAc = 1): Slightly greater than water.
Volatile Organic Compounds: 170 g/L (less water)
10. STABILITY AND REACTIVITY
CHEMICAL STABILITY:
Stable under normal conditions of use.
CONDITIONS TO AVOID:
Ignition sources and mixing with incompatibles.
INCOMPATIBLE MATERIALS:
Alkalis (caustics) and oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS:
Decomposes on heating emitting oxides of carbon, elemental entities, phosphates and noxious smoke.
HAZARDOUS REACTIONS:
Will not occur.
11. TOXICOLOGICAL INFORMATION
No adverse health effects are expected, if the product is handled in accordance with this Material Safety Data Sheet and
the product label. Symptoms and effects that may arise if the product is mishandled and overexposure occurs are:
ACUTE HEALTH EFFECTS:
Swallowed:
May cause irritation to mouth, throat and stomach with effects including pains in the stomach, which may lead to
nausea, vomiting and diarrhoea.
Eye:
Will cause irritation to the eyes, with effects including: tearing, pain, stinging and blurred vision.
Material Safety Data Sheet
Page 5 of 6 Issue date: July 2006
GC ADHESIVE
11. TOXICOLOGICAL INFORMATION (Continued)
Skin:
May cause irritation to the skin, with effects including; Redness and itchiness.
Inhaled:
Mists from the product may cause irritation to the nose, throat and respiratory system.
Chronic:
Prolonged or repeated skin contact may lead to dermatitis. Prolonged eye contact may lead to permanent eye injury.
Phosphoric acid:
Oral LD50(rat): 1,530 mg/kg
Inhalation LC50(rat): > 850 mg/m_/1 Hr
Dermal LD50(rabbit): 2,740 mg/kg
Ethanol:
Oral LDLo(Human): 1,400 mg/kg
Reaction: Stupor, sleepiness, headache.
Oral LD50(rat): 7,060 mg/kg
12. ECOLOGICAL INFORMATION
There is no ecological information available for this product, however, large quantities should not be discharged into
drains, sewers or waterways.
13. DISPOSAL CONSIDERATIONS
Refer to appropriate authority in your State. Dispose of material through a licensed waste contractor. Advise flammable
nature. If large amounts of the product enter waterways, sewers or streams, immediately contact the Environmental
Protection Agency or your Local Waste Management Authority.
14. TRANSPORT INFORMATION
Road Transport
UN Number: 1263
Proper Shipping Name: PAINT or PAINT RELATED MATERIAL
Dangerous Goods Class: 3
Packing Group: III
Label: Irritant (Xi), Flammable
Air Transport
UN Number: 1263
Proper Shipping Name: PAINT or PAINT RELATED MATERIAL
Dangerous Goods Class: 3
Packing Group: III
Label: Irritant (Xi), Flammable
Sea Transport
UN Number: 1263
Proper Shipping Name: PAINT or PAINT RELATED MATERIAL
Dangerous Goods Class: 3
Packing Group: III
Label: Irritant (Xi), Flammable
Material Safety Data Sheet
Page 6 of 6 Issue date: July 2006
GC ADHESIVE
15. REGULATORY INFORMATION
Poison Schedule: None allocated [Aust]
Inventory Status:
Australia (AICS) Y
United States (TSCA) Y
Europe (EINECS/ELINCS) Y
Y = all ingredients are on the inventory.
16. OTHER INFORMATION
Date of Preparation:
Issue date: July 12, 2006
Key Legend Information:
NOHSC - National Occupational Health & Safety Commission {Formerly Worksafe}[Aust]
ASCC - Australian Safety and Compensation Council [Aust]
SUSDP - Standard for the Uniform Scheduling of Drugs and Poisons [Aust]
TWA - Time Weighted Average [Int]
STEL - Short Term Exposure Limit [Int]
AICS - Australian Inventory of Chemical Substances
Dangerous Goods - Initial Emergency Response Guide (SAA/SNZ HB76:1997) [Aust]
TSCA - Toxic Substances Control Act [US]
AS/NZS 1715 - Selection, use and maintenance of respiratory protective devices. [Aust/NZ]
AS/NZS 1716 - Respiratory protective devices. [Aust/NZ]
Hazchem Code - Fire fighters designation [Aust]
IATA - International Aviation Transport Authority [Int]
IMDG - International Maritime Dangerous Goods [Int]
United Nations Recommendations for the Transport of Dangerous Goods and Globally Harmonized System for the
classification and labelling of Chemicals. [Int]
EINECS - European Inventory of Existing Commercial Chemical Substances. [Int]
ELINCS - European List of Notified Chemical Substances. [Int]
EU - European Union [Int]
EU Directives: The classification criteria used, are adopted from the European Community's (EC) legislation for
classifying dangerous substances. The criteria are taken from:
EC Council Directive 67/548/EEC
EC Council Directive 1999/45/EC
[Aust/NZ] = Australian New Zealand
[Int] = International
[US] = United States of America
Principal References:
Information supplied by manufacturer.
Disclaimer
To the best of our knowledge, the information provided above meets the requirements of European Union directives for
hazardous substances which have been tested as a whole. The data provided on this Material Safety Data Sheet is from
manufacturers of the original components. All animal test data has been obtained from the public domain, NO
ANIMAL TESTS have been conducted by Davidson Pty Ltd. Davidson Pty Ltd specifically disclaims any and all form
of liability and/or responsibility for the application of this product.
END of MSDS
|